Nationwide Boiler Inc
42400 Christy St
Fremont
CA
94538-4401
Tel: 800-227-1966
Fax: 510-490-0571
lday@nationwideboiler.com www.nationwideboiler.com
82500 PPH, Babcock & Wilcox, 500 PSI, Low NOx, Gas, No. 2 Oil, 5 ppm NOx option, New
[638]
One (1) Low NOx 82,500 lbs/hr* (99.9 MMBTUH input) Babcock and Wilcox package watertube boiler, 500-
sig design pressure, set to burn natural gas or No. 2 oil, including but not limited to the followin
scope of supply:
• Boiler with trim
Siteglass
Water column with high and low water alarms
Safety valves (shipped loose, set @ 500 psig)
Blowdown valves (bottom and surface mounted)
Feedwater stop and check valves
Low water cut-off (primary and secondary)
Single element pneumatic feedwater regulator with three-valve by-pass
(mounted)
• Low NOx Burner (25 ppm NOx while firing on natural gas w/FGR)
• Forced draft fan with 100 HP TEFC motor and starter (shipped loose)
• Burner Management System (Fireye E-110)
• Single point positioning combustion controls (Siemens 353 controller)
• Control circuit transformer
• NEMA 4 and 12 electrical enclosures and sealtite conduit for weather
Protection
• Fused combination starter and disconnect with single power supply connection
• No. 2 fuel oil pump mounted, piped and wired
• Eight inch non-return valve (shipped loose)
• Economizer (shipped loose)
• Stub stack (shipped loose)
• FGR ductwork (shipped loose)
• Boiler is designed for outdoor installation, weather protected except for freezing conditions
• All equipment shall meet FM, IRI, NFPA Insurance requirements
• Connection Sizes:
Steam: 8" 300 lb. R.F. flange
Oil: 1½" NPT supply, ¾" return
Natural Gas: 4" 150 lb. R.F. flange
Feedwater: 3” 300 lb. R.F. flange
Blowdown: 1½" 600 lb. R. F. flange
Continuous blowdown: 1" NPT
Atomizing air/steam: 1½" NPT
Chemical feed: 1" NPT
Instrument air: ¾” NPT
Water column drain: 2” NPT
Vent: 1” NPT
• Electrical Requirements: 480 volt, 3 ph, 60 hz 150 amp service required
• Dimensions and weights – Boiler and Burner only
Length: 30' - 0"
Width: 11'-10"
Height: 13'-8"
Shipping weight: 101,200 lbs.
Flooded weight: 131,500 lbs
FD fan and motor: 2,000 lbs.
*Request drawing for boiler capacity chart and actual dimensions
For information on a specific piece of equipment, please contact the selling dealer directly.
UED-ed is published by
Used Equipment Directory
400 Morris Ave Ste 268, Denville NJ 07834
Robert Scofield, Publisher. Email: bobs@buyused.com,
Tel: 973-400-1790 Fax: 973-625-8933
|
